<form id="xri3z"><th id="xri3z"></th></form>

              保定漆彩建筑裝飾工程有限公司
              ?

              資訊分類

              更多

              產品分類

              更多

              最新資訊

              更多
              地址:河北省保定市順平縣永平大街118號
              郵箱:40423960@qq.com
              電話:15081222333 0312-7615081
              傳真:0312-7655558

              新聞中心

              當前位置:首頁 > 新聞中心 > 工人對保定環氧地坪地面施工控制要點

              工人對保定環氧地坪地面施工控制要點

              2021-10-19

              保定環氧地坪涂料的效果,表面堅硬平滑、抗沖擊性能好;色澤均勻、光亮、無接縫;保養方便、維修費用低,且有很好的裝飾效果。一、施工材料:主要材料為無溶劑型保定環氧地坪涂料環氧底漆、中涂和面涂;輔助材料為金剛砂和石英粉等。

              The effect of epoxy floor coating, surface hard and smooth, good impact resistance; uniform color, bright, seamless; easy maintenance, low maintenance costs, and has a good decorative effect. 1. Construction materials: The main materials are solvent-free floor coatings epoxy primer, intermediate coatings and topcoatings; auxiliary materials are Emery and quartz powder. 二、施工工藝

              Two. Construction technology


              1.基層處理

              1. grassroots treatment


              清理打磨,用砂輪打磨機把混凝土表面的浮粒、水泥浮漿以及粘附的垃圾雜物打磨掉,清掃干凈。地面縫隙用氣泵吹沖至無灰塵及雜物。

              Cleaning and grinding, grinding wheel grinding machine to the concrete surface of floating particles, cement slurry and adherent garbage debris grinding, clean up. The ground gap is blown to dust and debris by air pump.


              2.混凝土縫隙處理

              2. concrete slot treatment


              縫隙表面封堵密實。配合比為5∶1加入適量的金剛砂,調成稠粥狀。檢測車間東半部分中間往北先處理縫隙,其他部分均為后處理縫隙?;炷翑鄩K用切割機切成凹槽,使用柔性環氧樹脂砂漿進行填塞、平整處理。

              The surface of the slit is tightly packed. Mix 5 to 1, add the right amount of emery, and make the thick porridge. Check the east half part of the workshop to deal with the gap first, and the other parts are all post-processing gaps. The concrete fault block is cut into grooves by cutting machine, and is filled and leveled by flexible epoxy resin mortar.


              3.涂刷底漆

              3. priming paint

              "

              使用無溶劑型環氧底涂漆,底涂A黃色,底涂B黑褐色,配合比A∶B=4∶1,加入適量的金剛砂。使用專用滾刷先橫后豎滾刷2遍,要求滾刷均勻、無漏涂、無堆積。

              Using solvent-free epoxy primer, primer A yellow, primer B black brown, mix ratio A:B=4:1, adding appropriate amount of emery. Use the special rolling brush to brush the brush 2 times after rolling vertically and evenly.

              4.中涂砂漿

              4. medium mortar

              使用無溶劑型環氧中涂漆,按配合比5∶1混合后加適量40~100目石英砂攪拌均勻,用抹子滿刮1~2遍。固化后用專用砂輪機將刮紋等打磨平整。中涂完成,嚴禁任何人進入。

              Use solvent-free epoxy medium coat, mix in proportion to 5:1, add appropriate amount of 40-100 mesh quartz sand to stir evenly, scrape 1-2 times with a plaster. After curing, special scratching machine is used to smooth the scratch. No one is allowed to enter.

              5.面涂打底

              5. sides applied to the bottom.


              配合比A∶B=4∶1,A為面層的色涂料,B為白色涂料,不添加任何材料,滿刮一遍。周邊、設備邊緣使用面層涂料,用毛刷提前處理1遍。

              Mixture A:B=4:1, A is the surface color paint, B is the white paint, without adding any material, full scrape once. Use the surface coating on the periphery and equipment edge, and use the brush to deal with it 1 times in advance.

              6.涂刷面涂料

              6. brushing paint


              根據要求加入顏色,同樣按配合比A∶B=4∶1,A為面層的色涂料,B為白色涂料,另外用稀料調整稠度,調完后稀稠度達到把底漆顏色蓋上,且無針孔、氣泡等缺陷。第1遍滾涂橫刷且垂直,滾刷滾涂時橫豎滾涂各1遍,把基層全部覆蓋。

              According to the requirements to add color, the same mix proportion A: B = 4:1, A for the surface of the color paint, B for white paint, in addition to adjust the consistency with thinner, after adjusting the thinner consistency to the primer color cover, and no pinholes, bubbles and other defects. First times rolling and spreading horizontally and vertically, rolling and rolling, rolling and coating each other 1 times, covering all the grass-roots.


              7.耐磨層

              7. wear-resistant layer


              用環氧耐磨面漆滾涂1遍,可顯著提高保定環氧地坪光潔度和耐磨性能??偤穸纫鬄?~5?mm。

              Rolling with epoxy abrasion resistant finish for 1 times can significantly improve the finish and wear resistance of the floor. The total thickness required is 3~5 mm.

              8.養護

              8. maintenance

              自然養護或噴刷養護劑,養護7?d后,方能承受重負荷。養護期間避免水或其他溶液侵入表面。

              Natural curing or spray curing agent can withstand heavy load after curing for 7 d. During maintenance, avoid water or other solution to invade the surface.

              9.驗收

              9. acceptance

              溫度在25℃時,2~3?d可達強度設計值的80%。用小錘敲擊不空鼓;用2?m靠尺高差小于3~4?mm;用駕校貨車在地面上進行剎車試驗,面層無變化;接口處平整、顏色一致、無明顯施工滾筒及批刀痕跡,光澤度應不小于70%。涂膜外觀無針孔、無氣泡、無褶皺。大面積的施工觀感與試件進行比較不吸水,不粘灰。

              When the temperature is 25 degrees, the 2~3 value of D can reach 80% of the strength design value. The drum can not be knocked hollow with a small hammer; the height difference of 2_m is less than 3 ~ 4_m m; the brake test is carried out on the ground with a driving school truck, and the surface layer is unchanged; the interface is smooth, uniform in color, and there is no obvious traces of construction drum and batch knife, and the gloss should not be less than 70%. There is no pinhole, no bubbles and no wrinkles. A large area of construction is compared with the specimen without water absorption and no dust.


              三、基底混凝土縫隙缺陷、面層針孔的處理

              Three. Treatment of base concrete crevice defects and surface pinholes.


              (1)混凝土縫隙面層施工后,第2~3?d抽查,發現褶皺;第3~4?d抽查褶皺部位增高且空鼓,開始切縫,及時處理。

              (1) After the construction of concrete crevice surface layer, folds were found on the 2nd to 3rd_d spot checks, and the 3rd to 4th_d spot checks showed that the folds were increased and empty, and cracks were cut and treated in time.

              (2)面層針孔發現后,上人不粘腳時,馬上用排筆補刷。

              (2) when the surface pinhole is found, when the upper person does not stick to his feet, he will use a pen to brush.


              標簽:   保定環氧地坪 地坪 保定環氧地坪漆 保定環氧地坪施工
              卡通动漫第48页综合,欧美日韩亚洲中字国产,国产在线不卡一区二区,国产网爆抖音在线观看,亚洲 欧洲 日产,福利明星换脸范冰冰,国产自产对白一区